Yanmar 1GM10V Especificações descarregar pdf (Página 31)

4. Maintenance & Inspection

31

(3) Adjusting the Remote Control Cable

The various control levers on the engine

side are connected to the remote control

lever by the remote control cable. The

cable will become stretched and the

attachments loose after long hours of use

causing deviation. It is dangerous to

control operation under these conditions,

and the remote control cable must be

checked and adjusted periodically.

A) Adjusting the Governor Remote Con-

trol Cable

Check to see that the control lever on the

engine side moves to the high speed bolt

position and low speed bolt position when

the remote control lever is moved to

H(high speed) and L(low speed)

respectively.

When there is deviation, loosen the

bracket for the remote control cable on

the engine side and adjust.

Adjust the high speed bolt position first

and then adjust the low speed idling.

B) Adjusting the Clutch Remote Control

Cable

Check to see that the control lever moves

to the correct position when the remote

control handle is put in NEUTRAL,

FORWARD, REVERSE.

Use the NEUTRAL position as the

standard for adjustment. When there is

deviation, loosen the bracket for the

remote control cable on the clutch side

and adjust.

(4) Electric Operation

Before inspecting the electrical

system, be sure either to turn off the

battery switch or to disconnect the (-)

terminal of the earth cable. Otherwise,

a shortcircuit could cause a fire.

002540-00E

Ensure good ventilation when

charging the battery. The use of open

flames is strictly prohibited. Hydrogen

gas may also catch fire.

Battery fluid is diluted sulfuric acid. It

can blind you or burn your eyes or

skin. Wear goggles and gloves when

handling battery fluid. Should the fluid

be deposited on your skin, wash with a

large quantity of fresh water and seek

treatment from a doctor.

1) If operation continues with insufficient

battery fluid, the battery will be destroyed.

Check the fluid level periodically. If the

level is lower than specified, resupply bat-

tery fluid (available in the market) up to

the upper limit of the battery.

(Battery fluid tends to evaporate in high

temperatures, especially in summer. In

such cases, inspect the bettery earlier

than specified.)

2) If the engine speed will not rise and

the engine cannot be started, measure

the specific gravity with a pycnometre

(available in the market).

The specific gravity of the fluid when fully

charged is over 1.27(at 20°C).

Fluid with a specific gravity of below 1.24

needs charging. If the specific gravity

cannot be raised by charging, the battery

must be replaced.

The capacities of the standard

alternator and the recommended

battery assume only the power

necessary for regular operation.

If the power is also used for inboard

lighting or other purposes, the

generating and charging capacities

may be insufficient. In such cases,

consult your Yanmar dealer or

distributor.

002550-00E

GM OPERATION.book 31 ページ２００４年１０月４日　月曜日　午前１１時１１分

1 2 ... 26 27 28 29 30 31 32 33 34 35 36 ... 43 44

Comentários a estes Manuais

Sem comentários